Product ID:EPOXO 1000B NON-SKID FLOOR & DECK COATING PART A
MSDS Date:03/01/1987
FSC:5610
NIIN:00-857-4392
Kit Part:Y
MSDS Number: BBJCX

AMERICAN SAFETY TECHNOLOGIES INC

565 EAGLE ROCK AVENUE
ROSELAND, NJ 07068-5000
US

Emergency Phone: 201-403-5600

Info Phone: 201-403-5600

Cage: AMSAT

AMERICAN SAFETY TECHNOLOGIES INC.

ROSELAND, NJ 07068 US

Telephone: 800-424-9300

Cage: AMSAT

BISPHENOL A DIGLYCIDYL ETHER RESIN, EPOXY RESIN, EPON 820,

CAS: 25068-38-6

RTECS: KD4380000

Fraction By Weight: 8-10%

XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *97-3*

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 18-20%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM, SKIN

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

PROPYLENE GLYCOL METHYL ETHER (1-METHOXY-2-PROPANOL)

CAS: 107-98-2

RTECS: UB7700000

Fraction By Weight: 2%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

CRYSTALLINE-QUARTZ SILICA, SILICA DUST (SUSPECTED HUMAN

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 44-48%

OSHA PEL 10 MG/CUM %RESP SIO2

ACGIH TLV: 0.1 MG/CUM RESP DUST

LD50 LC50 Mixture:ORAL LD50(LAB ANIMAL): 5 G/KG (SEE SUPP)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SKIN: MAY CAUSE IRRITATION &
SENSITIZATION. EYES: MAY CAUSE IRRITATION & DAMAGE.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, DIZZINESS, UNCONSCIOUSNESS.
Medical Cond Aggravated by Exposure:RESPIRATORY DISEASES, SKIN
CONDITIONS, KIDNEY/LIVER DISEASE.

First Aid:EYES: FLUSH W/LARGE AMOUNTS OF WATER. INHALATION: REMOVE TO
FRESH AIR. GIVE CPR/OXYGEN IF NEEDED. SKIN: WASH W/SOAP & WATER.
INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.

Flash Point Method:PMCC
Flash Point:81F
Lower Limits:1
Upper Limits:12
Extinguishing Media:CHEMICAL FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR A SCBA W/FULL FACE PIECE IN POSITIVE
PRESSURE MODE.
Unusual Fire/Explosion Hazard:VAPORS ARE >AIR, MAY TRAVEL ALONG GROUND
& BE IGNITED BY FLAMES, SPARKS/OTHER IGNITION SOURCES.

Spill Release Procedures:REMOVE IGNITION SOURCES. ABSORB ON SAND,
CLAY/OTHER ABSORBENT MATERIAL & SHOVEL INTO CONTAINERS.

Handling and Storage Precautions:USE W/ADEQUATE VENTILATION. AVOID
EXTREME HEAT. KEEP AWAY FROM FLAME. STORE <110F.
Other Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING. AVOID
INHALATION OF VAPORS/MIST.

Respiratory Protection:WEAR A SCBA IF TLVS ARE EXCEEDED. WEAR PROPER
DUST MASK WHEN REMOVING OLD COATING BY SANDING/SANDBLASTING.
Ventilation:LOCAL EXHAUST: SUFFICIENT TO MAINTAIN LEVEL Protective Gloves:RUBBER/BUNA N
Eye Protection:CHEMICAL SPLASH GOGGLES
Other Protective Equipment:PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER/DISCARD CONTAMINATED CLOTHING
BEFORE REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
ORAL LD50 INFORMATION IS FOR EXPOXY RESINS.

Boiling Pt:B.P. Text:>240F
Vapor Pres:8
Vapor Density:3.7
Spec Gravity:1.7
Evaporation Rate & Reference:(BU AC = 1): 0.7
Solubility in Water:SLIGHT
Appearance and Odor:VISCOUS PASTE W/MILD ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, ALKALIES, AMINES, OXIDIZING AGENTS.
Stability Condition to Avoid:FLAMES, SPARKS & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:BY BURNING: CO, CO2 & TOXIC FUMES.

Waste Disposal Methods:DISPOSE OF BY CONTROLLED BURNING/IN AUTHORIZED
LANDFILL IAW/FEDERAL, STATE & LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.